Results 1 to 5 of 5

Thread: carrier 30 rb

  1. #1
    Join Date
    Apr 2009
    Location
    israel
    Age
    50
    Posts
    778
    Rep Power
    18

    carrier 30 rb



    Hi
    fault p-32 p-33
    water pump fault ,i bridged input but still have this fault alarm .
    any ideas?except for replacing card!


    THE DEFINITION OF A SMART PERSON IS ONE WHOM LEARNS FROM HIS MISTAKES!!!

  2. #2
    Join Date
    Oct 2007
    Location
    manchester
    Age
    50
    Posts
    5,707
    Rep Power
    45

    Re: carrier 30 rb

    Cooler Pump Fault
    P.32 — Pump 1 Fault
    P.33 — Pump 2 Fault
    Criteria for Trip
    — The criterion is tested whether the units are
    ON or OFF. This alarm will be generated if the cooler pump
    interlock opens. When starting the pump, the control must read
    an open circuit for 3 consecutive reads. If the pump is operating
    and the circuit opens, the alarm will be generated immediately.
    Action to be Taken
    — The pump and machine will be shut
    down. If there is another pump available, the control will start
    that pump, restart the machine and clear the alarm. If no other
    pump is available, the unit will remain OFF.
    Reset Method
    — Manual.
    Possible Causes
    — If this condition is encountered, check the
    following items:
    • Check the interlock wiring circuit.
    • Check for a control signal to the pump controller.
    • Check the cooler pump contactor for proper operation.
    • Check control voltage for proper voltage. On 208-volt
    systems, be sure the proper tap on TRAN1 is utilized.

  3. #3
    Join Date
    Apr 2009
    Location
    israel
    Age
    50
    Posts
    778
    Rep Power
    18

    Re: carrier 30 rb

    Hi IM
    THX CHECKED ALL THAT ,ILL BE ON SITE AND CHECK AGAIN.
    THE DEFINITION OF A SMART PERSON IS ONE WHOM LEARNS FROM HIS MISTAKES!!!

  4. #4
    Join Date
    Oct 2007
    Location
    manchester
    Age
    50
    Posts
    5,707
    Rep Power
    45

    Re: carrier 30 rb

    https://rapidshare.com/files/2878700323/30rb-4t.pdf;
    30rb manual- incase you havent got it

  5. #5
    Join Date
    Apr 2009
    Location
    israel
    Age
    50
    Posts
    778
    Rep Power
    18

    Re: carrier 30 rb

    Hi

    turns out its the flowswitch!
    they both sit on the same alarm !!!!p32-33
    no seperate alarm for the flow!
    i was wondering, this electronic flowswitch sends a signal via a resistor to a discreet input(ch15b) .
    could this input be bridged??
    thx for response
    THE DEFINITION OF A SMART PERSON IS ONE WHOM LEARNS FROM HIS MISTAKES!!!

Posting Permissions

  • You may not post new threads
  • You may not post replies
  • You may not post attachments
  • You may not edit your posts
  •